Highly selective etching for polysilicon and etch-induced damage to gate oxide with halogen-bearing electron-cyclotron-resonance plasma

Kow-Ming Chang*, Ta Hsun Yeh, I. Chung Deng, Horng-Chih Lin

*此作品的通信作者

研究成果: Article同行評審

27 引文 斯高帕斯(Scopus)

摘要

The investigations of polysilicon etching with three halogen-bearing plasmas (SF6, Cl2, and HBr) in an electron-cyclotron-resonance reactor have been made. We examine the etching characteristics which include etching rate, anisotropy, and selectivity based on the discussions of the chemical and electrical properties of the F, Cl, and Br radicals. It was found that the degree of anisotropy strongly depends on the deposition of a silicon halide film on sidewall and on the spontaneous etching properties of three halogen plasma mixtures. The selectivity to oxide is related to the amount of silicon halides that are produced during etching poly-Si and the electrically polarized level of these products when they adsorb on the oxide surface. We find that the selectivity on oxide is approximately infinite for the HBr system and over 90 for the Cl2 system. In addition, the effects of oxygen addition, microwave power, and rf power are also investigated. It was found that the maximum etching rate and selectivity of SF6, Cl2, and HBr plasmas occurred at concentrations of added oxygen at about 7.5%, 5%, and 3% total flow rates, respectively. The suitable range for the microwave power applied is from 250 to 300 W and the most respectable value of applied rf power is about 35 W. Concurrently, the local surface charging causing damage to the gate oxide during the overetching period is studied. It is observed that low device yield, large flatband voltage Vfb shift, and high interface-state density Dit are correlated with longer overetch and high antenna ratio structure of the device. A more obvious degradation is observed in the SF6 gaseous system than in Cl2 and HBr ones. Finally, the influence of magnetic coil current on device damage is also addressed

原文English
頁(從 - 到)3048-3055
頁數8
期刊Journal of Applied Physics
80
發行號5
DOIs
出版狀態Published - 1 9月 1996

指紋

深入研究「Highly selective etching for polysilicon and etch-induced damage to gate oxide with halogen-bearing electron-cyclotron-resonance plasma」主題。共同形成了獨特的指紋。

引用此